effect of granulated slag as sand replacement in concrete
(PDF) EFFECT OF PARTIAL REPLACEMENT OF SAND BY IRON SLAG ,, The report presents an investigation of mechanical and durability properties of concrete by adding iron slag as replacement of sand in various percentag The X-ray diffraction analysis carried out in this paper gives a deeper insight in the mineralogical constitution and behavior of such slags when used for construction purposEffect of Granulated Blast Furnace Slag (GBS) Sand on ,, Effect of Granulated Blast Furnace Slag (GBS) Sand on Strength and Durability of Concrete Laveshkumar U Pawar Prof M M Magdum , Water absorption is less in case of GBS sand concrete 50% replacement of river sand with GBS sand shows minimum percentage of water absorptionLiterature review of a granulated blast furnace slag as a ,, Literature review of a granulated blast furnace slag as a replacement of sand Products As a leading global manufacturer of crushing, grinding and mining equipments, we offer advanced, reasonable solutions for any size-reduction requirements including, Literature review of a granulated blast furnace slag as a replacement of sand, quarry, aggregate, and different kinds of mineralsImpact of Ground Granulated Blast Furnace Slag on High ,, Ground Granulated Blast Furnace Slag (GGBS) GGBS, being the by-product from blast furnace, contains cementitious properti To develop ultra high-performance concrete, higher cement content (>600kg/m3) is required, which in turn, results in higher heat of hydrationGround Granulated Blast Furnace Slag, LF Kahn, in Corrosion of Steel in Concrete Structures, 2016 Slag Ground granulated blast-furnace slag, more commonly referred to as slag or slag cement, is a by-product of steel production Slag is primarily composed of CaO, SiO 2, aluminum oxide (Al 2 O 3), and magnesium oxide (MgO) When used as part of a portland cement concrete, slag ,.
(PDF) Effect of partial replacement of cement by ground ,, Effect of partial replacement of cement by ground granulated blast furnace slag and sand by iron ore tailings on properties of concrete August 2018 International Journal of Advanced Technology and ,Effect of Recycled Aggregate and Iron Slag in Concrete ,, strength Fine aggregate replacement for 40%, 60%,80% with iron slag was found to be good, increase in strength was found when compared to control concrete Replacement of sand with iron slag for 80% and was found to be less when compared to control concrete Over all iron slag can be used as a replacement materialInfluence of Local Sand on the Physicomechanical ,, This research consists of incorporating the crushed sand (CS) in the composition of a concrete and studies the effect of its gradual replacement by the sand dune (SD) on sustainability of high performance concrete (HPC) in aggressive environments The experimental study shows that the parameters of workability of HPC are improved when the CS is partially replaced by the SD (<2/3)Effect of Ground Granulated Blast Furnace Slag on the ,, This paper opens up how the properties of seashell mix concrete influenced by the effect of ground granulated blast furnace slag (GGBS) This experimental program consists of thirteen concrete mix One is conventional concrete & other concrete mixes are formed by the partial replacement of fine aggregate with crushed seashell and cement with GGBS The proportion of crushed seashell was ,Effect of Glass Powder on Concrete Sustainability, pozzolanic properti This paper focuses on characterization and the effect of GP on concrete properties compared to those of Class F fly ash (FFA) and ground granulated blast furnace slag (GGBS) Concrete incorporating 0, 20 and 30% of GP and other concrete mixes containing 30%of FFA or GGBS were cast.
Effect of copper slag and granite dust as sand replacement ,, Nov 07, 2020· The SEM images of the control concrete and specimen with 30% CS + GD replacement showed that there was sufficient C-S-H gel available to bind the CS particle, GD, sand, coarse aggregates together; however, the SEM images of the specimen with 40%-50% copper slag replacement showed that sufficient C-S-H gel could not bind the ingredients in the ,(PDF) " Ground Granulated Blast Slag (GGBS) In Concrete ,, The quenching optimises the cementitious properties and produces granules similar to coarse sand This "granulated" slag is then dried and ground to a fine powderAlthough normally designated as "GGBS" in the UK, it can also be referred to as "GGBS" or "Slag cement" Concrete is basically a mix of fine aggregate, coarse aggregate and cement ,Effects of Ground Granulated Blast Furnace Slag in ,, Effects of Ground Granulated Blast Furnace Slag in Portland Cement Concrete (PCC)-Wisconsin Highway Research Program WHRP 07-01 Irene K LaBarca, Ryan D Foley, Steven M Cramer Department of Civil and Environmental Engineering University of Wisconsin-Madison January 2007 Expanded Study SPR # 0092-05-01An Experimental Investigation on Properties of Concrete by ,, Dec 12, 2017· Ground Granulated Blast Furnace Slag is a by-product of Iron and Steel industry which is produced in large quantities as a solid wasteIt is highly cementitious, Quarry Dust is used as a replacement of Natural Sand due to its scarcity The replacement percentages of Cement with GGBS are 20 %, 40 % and 60 % by weight and 25 %, 50 %, 75 % and 100 ,Effect of 30% Ground Granulated Blast Furnace, Lead and ,, This paper investigates the effects of using Ground Granulated Blast Furnace Slag (GGBFS), Lead Slag (LS) and Zinc Slag (ZS) as replacement for sand on the strength of concrete Compressive strength, flexural strength, water absorption and density were tested at 14, 28 and 56 days In this study, a total of 40 concrete samples, including Pozzolanic Portland Cement (PPC), GGBFS, LS and ZS ,.
Fly Ash, Slag, Silica Fume, and Natural Pozzolans, Chapter 3, and the desired effects on the concrete (Helmuth 1987 and ACI 232 1996) SLAG Ground granulated blast-furnace slag (Fig 3-5), also called slag cement, is made from iron blast-furnace slag; it is a nonmetallic hydraulic cement consisting essentially of sili-cates and aluminosilicates of ,An Experimental Study on High Performance Concrete Using ,, granulated blast furnace slag (10 %, 20 %, 30 % and 40%) and Fly ash (10 %, 20 %, 30 % and 40%) to obtain the desired strengths and properti Finally, we used in combination of fly ash and ground granulated blast furnace slag in different percentages as replacement of cement and concrete ,Ground Granulated Blast Furnace Slag in Concrete and its ,, The ground granulated blast furnace slag (GGBFS) is a by-product of iron manufacturing which when added to concrete improves its properties such as workability, strength and durability This material is obtained by the heating of iron ore, limestone and coke at a temperature about 1500 degree CelsiusParticle Size Effect of Ground Granulated Blast Furnace ,, Particle Size Effect of Ground Granulated Blast Furnace Slag (GGBS) in Cement Concrete V Nagendra 1, C Sashidhar 2, S M Prasanna Kumar 3, N Venkata Ramana 4 1Civil Engineering Department, Nagarjuna College of E ngineering and Technology, Bengaluru, Karnataka, India 2Civil Engineering Department, JNTUA ,Anantapur, A P, IndiaTHE EFFECT OF REPLACEMENT OF NATURALS AGGREGATES BY SLAG ,, The aggregates (sand and gravel) form the skeleton of the concrete; they occupy approximately 75% of its volume, and intervene directly on the physical and mechanical properties of concrete The aim objective of this experimental work consists in: - Substituting sand by granulated blast furnace slag.
Effect of nickel slag as a sand replacement in strength ,, Concrete containing cement, sand, gravel, nickel slag, water and superplasticizer were processed using normal intensive mixing The strength of concrete is determined by the interfacial zone between binder paste and aggregat Due to the weathering of natural aggregates with time, a morphology with rounded edges is obtained, reducing the interlocking with the pasteThe effect of attack of chloride and sulphate on ground ,, The effect of attack of chloride and sulphate on ground granulated blast furnace slag concrete Deepankar K Ashish*1,2, Bhupinder Singh3a and Surender K Verma1b 1Department of Civil Engineering, PEC University of Technology, Chandigarh160-012, India 2Maharaja Agrasen Institute of Technology, Maharaja Agrasen University, Baddi 174103, India(PDF) Effect of Partial Replacement of Sand by Iron Ore ,, Effect of Partial Replacement of Sand by Iron Ore Tailing (IOT) and Cement by Ground Granulated Blast Furnace Slag (GGBFS) on the Compressive Strength of Concrete ,Use of Granulated Blast, Keywords: aggregates; durability; slag cement Date: 5/1/2006 Abstract: This paper reports the results of some experimental studies on the use of non-ground-granulated blast-furnace slag (NGGBFS) as fine aggregate in concrete Two groups of concrete samples were produced The NGGBFS/sand ratios were 0% (reference), 25, 50, 75, and effect of granulated slag as sand replacement in concrete, Effect of 30% Ground Granulated Blast , This paper investigates the effects of using Ground Granulated Blast Furnace Slag (GGBFS), Lead Slag (LS) and Zinc Slag (ZS) as replacement for sand on the strength of concrete Compressive strength, flexural strength, water absorption and density were tested at 14, 28 and 56 days Know More.
Slag Cement Benefits and Use in Concrete, Slag cement is commonly found in ready-mixed concrete, precast concrete, masonry, soil cement and high temperature resistant building products While there are many applications and benefits of slag cement, a few are highlighted below and detailed information sheets are located herePAPER OPEN ACCESS Effect of Ground Granulated Blast ,, Effect of Ground Granulated Blast Furnace Slag as Partial Replacement in Fly Ash-Based Geopolymer Concrete To cite this article: M F A Abdul Sani et al 2020 IOP Conf Ser: Mater Sci Eng 712 012002 View the article online for updates and enhancements This content was downloaded from IP address 2074613204 on 05/05/2020 at 05:27Effect of Nano, The current study investigates the performance of concrete incorporating ground granulated blast-furnace (GGBF) slag in the presence of colloidal nano-silica A control group of concrete mixtures is compared with a group of mixtures with 50% slag replacement, with each group examined at two different ratios of colloidal nano-silica (3% and 6% ,The Exploitation of Blast furnace Slag as Sand Replacement ,, improvement by the use of ground granulated blast furnace slag as a replacement of sand in concrete mixtur The optimum percentage is between 30 % and 40 %, after those percentages there is no observed increase Keywords: Concrete; Compressive strength; Flexural properties; Ground granulated blast furnace slag, replacement as a sand I ,The Use of Granulated Copper Slag as Cement Replacement ,, copper slag in concrete production Copper slag is one of the by-product materials from the copper smelting In Indonesia, around 400,000 tons of copper slag are produced per year by Freeport Company and Newmont Company  This number is a motivation for the researchers to study the copper slag as aggregate or cement replacement in concrete.